Dodge Diesel - Diesel Truck Resource Forums - Search Results

 
Search: Posts Made By: BigIron70
Showing results 1 to 25 of 500
Search took 0.10 seconds.
Replies: 5
Views: 1,040
Posted By BigIron70

Make sure valve spring did not break or possible...

Make sure valve spring did not break or possible bent valve. Rocker arm damage or missing part of rocker arm which contacts the valve stem. Adjuster lock nut not tight and adjuster backed off....
09-10-2018, 01:42 AM
Replies: 9
Views: 1,051
Posted By BigIron70

Check for broken valve spring,

Check for broken valve spring,
09-07-2018, 11:52 PM
Replies: 5
Views: 963
Posted By BigIron70

Special tools are required to check fuel injector...

Special tools are required to check fuel injector return flow and PLV for leakage. I would purchased injector cap off tool and cap off injectors one by one until you locate injector causing the no...
08-28-2018, 02:41 AM
Replies: 13
Views: 1,133
Posted By BigIron70

Usually I have found steering box causing this...

Usually I have found steering box causing this problem. Check up and down play on shaft use pry bar if play is excessive you will need gear box. Chrysler has also updated gear box which will fix...
08-27-2018, 02:50 PM
Replies: 1
Views: 523
Posted By BigIron70

Did you remove cylinder head? Did you set valve...

Did you remove cylinder head? Did you set valve clearance to spec?
08-06-2018, 10:31 AM
Replies: 5
Views: 966
Posted By BigIron70

REGEN? truck is blowing black smoke then DPF is...

REGEN? truck is blowing black smoke then DPF is no good, (cracked internally) , Over fueling most likely injectors are stuck, is oil level overfull mark? Air filter not plugged? no leaking boost...
08-06-2018, 10:19 AM
Replies: 2
Views: 364
Posted By BigIron70

Sounds like the starter is bad, brushes worn out....

Sounds like the starter is bad, brushes worn out. If batteries and connections are clean and tight. Try tapping starter motor while someone turns ignition key, if it starts then replace starter or...
Replies: 5
Views: 554
Posted By BigIron70

I have never had luck with a Napa gear box. I've...

I have never had luck with a Napa gear box. I've always had to replace within a few days. Disconnect pitman arm and check if still binding. I would get my money back and get factory gear box. The...
Replies: 5
Views: 606
Posted By BigIron70

Most likely the evaporator is leaking. If you...

Most likely the evaporator is leaking. If you have R134 sniffer check the vents when ac is on. You can also inject dye into system and check with black light and special glasses. Best to take into...
Forum: HELP!
07-11-2018, 12:50 PM
Replies: 3
Views: 1,482
Posted By BigIron70

I think you answered your own question. You need...

I think you answered your own question. You need to put tuner back or perform edge tuner removal procedure to reset ecm.
06-16-2018, 10:57 AM
Replies: 19
Views: 3,919
Posted By BigIron70

I call it job security, keeps me busy all day.

I call it job security, keeps me busy all day.
06-15-2018, 10:41 PM
Replies: 18
Views: 122,606
Posted By BigIron70

This is what happens when you continue to drive...

This is what happens when you continue to drive when DPF will not go into a REGEN
06-15-2018, 10:09 PM
Replies: 5
Views: 706
Posted By BigIron70

Would make me start drinking again if I saw that...

Would make me start drinking again if I saw that under my truck.
04-04-2018, 07:40 PM
Replies: 16
Views: 4,046
Posted By BigIron70

Mostly labor removing fuel tank, fuel lines and...

Mostly labor removing fuel tank, fuel lines and fuel rail, fuel filters, flushing fuel lines with clean fuel and fuel rail. I've spent 12 hours cleaning out fuel system. Then road testing and...
04-02-2018, 12:36 PM
Replies: 278
Views: 44,812
Posted By BigIron70

Oli would you have a drive gear for injection...

Oli would you have a drive gear for injection pump and drive gear for vac pump? or complete vac pump dual diapharm type. Gears got damage on mine need to replace.
Thanks for any help
Bill
03-25-2018, 10:50 PM
Replies: 2
Views: 365
Posted By BigIron70

I have seen that problem only once in 30 years...

I have seen that problem only once in 30 years working on Cummins diesel trucks and it was the ECM causing the problem.
02-06-2018, 06:24 PM
Replies: 20
Views: 1,601
Posted By BigIron70

Takes any fan off in 2 seconds.

Takes any fan off in 2 seconds.
02-06-2018, 06:15 PM
Replies: 20
Views: 1,601
Posted By BigIron70

I use this tool works great removing and...

I use this tool works great removing and installing
02-05-2018, 10:05 PM
Replies: 1
Views: 2,331
Posted By BigIron70

Make sure you disconnect grid heater when you use...

Make sure you disconnect grid heater when you use either, unless you like really loud noises when the either ignites in the intake. You need to monitor fuel rail pressure when cranking over engine. ...
12-23-2017, 10:36 PM
Replies: 83
Views: 7,927
Posted By BigIron70

I just hope President Trump follows through with...

I just hope President Trump follows through with his immigration plans. Stop chain migration and band all immigration from terrorist controlled countries. That would stop 90% of future attacks in...
12-08-2017, 09:02 PM
Replies: 13
Views: 915
Posted By BigIron70

Cracked injector only way I've found to locate...

Cracked injector only way I've found to locate other then pulling all 6 injectors and testing.
Remove valve cover and start engine, leaking injector will have fine mist shooting out from bad...
12-01-2017, 08:45 PM
Replies: 5
Views: 742
Posted By BigIron70

Last year for a 5.9 was 2007 not 2017, If you...

Last year for a 5.9 was 2007 not 2017, If you have a 2017 then it is a 6.7 and still under warranty. Your signature is 2007 so I assume that is the correct year. I have seen this code many times but...
11-22-2017, 03:33 PM
Replies: 1
Views: 367
Posted By BigIron70

Leaking injector, you can try capping each...

Leaking injector, you can try capping each injector at rail one at a time until you find one causing no start. You need this capping tool....
11-19-2017, 06:26 PM
Replies: 11
Views: 2,408
Posted By BigIron70

Always use synthetic oil in HD differentials and...

Always use synthetic oil in HD differentials and when used for towing. Synthetic does not break down under high temperatures.
11-13-2017, 10:36 PM
Replies: 3
Views: 405
Posted By BigIron70

Possible you left the ground wire off from the...

Possible you left the ground wire off from the ECM? It goes directly to ECM on the left side of engine block and then to battery ground. If not connected will cause a no start.
Showing results 1 to 25 of 500
 


 
Forum Jump

Contact Us - Archive - Advertising - Cookie Policy - Privacy Statement - Terms of Service

© 2019 MH Sub I, LLC dba Internet Brands

We are a participant in the Amazon Services LLC Associates Program, an affiliate advertising program designed to provide a means for us to earn fees by linking to Amazon.com and affiliated sites.