Throttle sticking on an 03
#1
Throttle sticking on an 03
My wife said that after she drove our 2003 4x4 3500 dually over a mountain she had three seperate times where the throttle stuck to the floor and she could not pull it back up. It happened three times after using the passing lanes and it scared her. It was not caught under the floor mat.
Truck has 144,156 and is out of warranty. Any help would be appreciated
Truck has 144,156 and is out of warranty. Any help would be appreciated
#2
Was it a mechanical stick? or Electrical? Open the hood and removethe cover off the APPS sensor. ( black box drivers side of valve cover in front of intake horn) from there remove the throttle cable and you should be able to tell if there is any binding in the cable,pedal or linkage. cable should move the pedal with ease. If that checks out, it might be a problem with the APPS. Check for DTCs by turning your key on and off 3 times ending in the on position. If the APPS is the problem it should store the code.
Dave
Dave
#3
Registered User
Join Date: Jan 2007
Location: In Oroville, Ca., same house for past 46 yrs!
Posts: 719
Likes: 0
Received 0 Likes
on
0 Posts
My neighbor has a 4 x 4 like mine and his stuck once on him. Traced the problem to a broken wire in the cable. When you mashed the throttle all the way down, the little wire strand that was broken would stick out of the sheath. New cable, no problem now. Maybe your's has a broken strand somewhere, look there too.
#4
I watch wind blow...
Join Date: Dec 2006
Location: Red Dirt territory of TEXAS
Posts: 1,390
Likes: 0
Received 0 Likes
on
0 Posts
Open the hood and removethe cover off the APPS sensor. ( black box drivers side of valve cover in front of intake horn) from there remove the throttle cable and you should be able to tell if there is any binding in the cable,pedal or linkage. cable should move the pedal with ease. If that checks out, it might be a problem with the APPS. Check for DTCs by turning your key on and off 3 times ending in the on position. If the APPS is the problem it should store the code.
Dave
Dave
#5
I guess I was under the impression all 03's were in front of the intake horn. The two other places I know they're located is under driverside battery or on the throttle pedal itself.
Dave
Dave
Thread
Thread Starter
Forum
Replies
Last Post